Ariens 992807-ProZoom 60 Specifications download pdf (Page 35)

Replacetheinnercartridge(6)yearlyor

every250hourswhichevercomesfirst.

IMPORTANT:DONOTattempttocleanthe

secondaryelement.Thisfilterelementmust

bereplacedifitisunusuallydirtyor

damaged.

NOTE:Operationindustyconditionsmay

requiremorefrequentmaintenanceofthe

primaryandsecondaryaircleanercartridges.

CAUTION:Donotuse

,_ pressurized air to clean paper

element.

FUEL SYSTEM SERVICE

,&

CAUTION: Fuel vapors are

explosive and flammable. Do not

smoke while handling fuel. Keep

fuel away from flames or sparks.

Shut off engine before servicing.

Always work in a well-ventilated

area. Clean up spilled fuel

immediately.

Be sure the engine is stopped, the

steering control levers are in the

park position and the key is

removed before making these

repairs.

Be sure to inspect the fuel lines

periodically. The lines are subject

to deterioration and wear. Fuel

could leak out onto a running

engine and cause a fire.

WARNING: Improper use of

solvents can result in fire or

explosion. Do not use gasoline or

low flash point solvents to clean

the fuel filter and/or the fuel pump.

Clean only in a well-ventilated

area away from sources of sparks

or flame, including any appliances

with a pilot light.

IMPORTANT: Special care should be taken

when the fuel lines are removed for

maintenance or repair. Close both ends of the

fuel line with a piece of paper or a clean cloth

to prevent dust or dirt particles from

contaminating the fuel. Even a small amount

of dust or dirt can cause premature wear or

failure of fuel components.

The fuel line connections are composed of

rubber and they will age regardless of the

service period. If there is any deterioration of

the fuel lines or clamps, replace them.

Check the fuel filter regularly. If it is clogged

by debris or contaminated with water, replace

it.

The fuel filter cannot be disassembled. If the

fuel filter becomes clogged, replace it with a

new one.

1. Park the machine safely in a well-

ventilated area.

2. Allow to cool.

3. Compress hose with clamp between

tank and filter. Use care not to damage

or puncture hose.

4. Disconnect the hose clamps (1) from the

fuel filter (see figure 25).

5. Slide the fuel line off of both ends of the

fuel filter (2).

6. Install the new fuel filter paying close

attention to the flow direction (3) noted

on the fuel filter.

7. Remove clamp.

The fuel pump can not be disassembled. If

the fuel pump fails, replace it with a new one.

Fuel Filter

Hose Clamps

Figure 25 OE3336

SPARK PLUG SERVICE

,_ WARNING: Hot enginecomponents can cause severe

burns. Stop engine and allow it

to cool before checking the

spark plug.

Clean or replace the spark plug and reset the

gap every 100 hours of operation.

1. Disconnect the spark plug wire lead and

remove the spark plug.

GB - 35

1 2 ... 30 31 32 33 34 35 36 37 38 39 40 ... 105 106

Comments to this Manuals

No comments