Ariens 992807-ProZoom 60 Specifications download pdf (Page 12)

GB - 12

SETUP INSTRUCTIONS

Ariens mowers are shipped partially

assembled. After uncrating the power unit

and mower deck, initial setup is required.

IMPORTANT: During the unpacking of the

crate all goods should be matched against

the packing list and all shortages or damages

should be noted and reported to the carrier

immediately.

Steering Controls

1. The steering control levers may have

been loosened and moved forward for

shipping. Remove the loose 3/8-16 x

1.75" bolts from the handles and reinstall

them in the location shown. Adjust the

handles to fit your comfort area.

Seat Setup

1. Remove the loose 3/8" clevis pin, two

flat washers and rue ring from the

manual pack.

2. Carefully rotate the seat plate forward

far enough to install the seat support bar

in the location shown in figure 4.

3. Connect the seat suport bar to the

bottom of the seat plate using the 3/8"

clevis pin, two 3/8" flat steel washers

and the rue ring.

4. Return seat plate to operating position

and engage seat lock.

Battery

The battery supplied with the mower is

sealed, it will not be necessary to activate it.

1. Connect the red positive cable to the

positive (+) side of battery. Use 1/4 x

5/8" bolt and 1/4" locknut. Cover

terminal with rubber boot.

2. Connect the black negative cable to

Negative ( - ) side of battery. Use 1/4 x

5/8" bolt and 1/4" locknut.

If the engine does not turn over by turning the

ignition switch, it may be necessary to charge

the battery. (See Charging the Battery on

page 31.)

Deck

1. Remove knob from discharge shield.

2. Remove discharge assembly from

Transport position.

3. Install discharge assembly in Operating

position.

4. Reinstall knob in discharge assembly

and tighten.

CAUTION: Ensure that seat lock

is latched and fully engaged

when returning seat plate to

operating position.

Figure 3

Install

Bolt

Here

Figure 4

1. Seat Support Bar

2. Seat Plate

3. Seat Lock

4. 3/8 in. Clevis Pin

5. Flat Washer

6. Rue Ring

1

3

4

5

6

5

2

1 2 ... 7 8 9 10 11 12 13 14 15 16 17 ... 49 50

Comments to this Manuals

No comments