Ariens 936036 - 2548 Specifications download pdf (Page 15)

GB - 15

STEERING ADJUSTMENT

If steering system feels loose, ensure hardware is tight

and check wear points for excessive wear. Replace parts

as needed.

If tractor wanders or excessive tire wear develops, toe-in

should be checked. Front of wheels should be 1/16 in. to

1/8 in. (2 to 3 mm) closer together than rear of wheels. To

correct toe-in:

1. Loosen jam nuts at tie rod ends.

2. Turn tie rod clockwise to increase distance between

front of wheels. Turn tie rod counterclockwise to

decrease distance between front of wheels.

3. Tighten jam nuts at tie rod ends.

PARKING BRAKE SPRING

Compress the spring to the length indicated with the

brake on (Park Brake Set). Turn the locknut to adjust

(figure 14).

DISC BRAKE ADJUSTMENT

To check and change disc brake setting (figure 15):

1. Place feeler gauge between the two discs. With

clutch/brake pedal released there should be

0.015 in. to 0.025 in. (0.4 mm to 0.6 mm) clearance.

2. Tighten castellated nut to decrease clearance,

loosen to increase clearance.

3. Adjust brake spring. Turn nylon locknut until brake

spring is compressed to 7/8 in. (22 mm) when brake

pedal is depressed.

NEUTRAL ADJUSTMENT (936036)

Adjust neutral if tractor moves when forward or reverse

pedal is not depressed. To adjust neutral (figure 16):

1. Prop right rear wheel off the ground.

2. Spin right rear wheel. Turn neutral adjustment bolt

until rear wheel no longer spins.

BATTERY

Battery Electrolyte First Aid

Follow First Aid directions for contact with battery ﬂuid.

• External Contact: Flush with water.

• Eyes: Flush with water for at least 15 minutes and

get medical attention immediately!

• Internal Contact: Drink large quantities of water.

Follow with Milk of Magnesia, beaten egg or

vegetable oil. Get medical attention immediately!

In case of internal contact, DO NOT induce vomiting!

IMPORTANT:

DO NOT fast charge. Charging at a higher

rate will damage or destroy battery. ONLY use an

automatic charger designed for use with your battery.

1-13/16 in. (4.6 cm)

OT0351

Figure 14

1. Brake Rod

2. Compression Spring

3. Lock Nut

OT0840

Figure 15

7/8

in.

22 mm

1. Disc Brake

2. Castellated Nut

w/Cotter Pin

3. Compression Spring

4. Feeler Gauge

5. Washer

6. Nylon Locknut

WARNING:

AVOID INJURY. Read and

understand the entire

Safety

section before

proceeding.

WARNING:

Battery posts, terminals and related

accessories contain lead and lead compounds,

chemicals known to the State of California to

cause cancer and reproductive harm. Wash

hands after handling.

Figure 16

Neutral

Adjustment

Bolt

OT0041

1 2 ... 10 11 12 13 14 15 16 17 18 19 20

Comments to this Manuals

No comments

Ariens 936036 - 2548 Specifications Page 15

Comments to this Manuals

Related products and manuals for Garden tools Ariens 936036 - 2548