Owner/Operator ManualModels991085 – Max Zoom 48991086 – Max Zoom 52991087 – Max Zoom 60Max Zoom™04276000A 10/10Printed in USAENGLISHFRANÇAIS
GB - 10UNIT ASSEMBLYPackage Contents: Unit, Mower Deck and Literature PackPreparation ChecklistRefer to the Owner/Operator manual as required.1. Unpa
GB - 1110. Check Safety Interlock System - Check to see that the interlock system operates correctly (See Safety Interlock System on page 12).11. Lubr
GB - 12CONTROLS AND FEATURESSee Figure 4 for Controls and Features locations.Safety Interlock SystemPerform the following tests to ensure the safety i
GB - 13Throttle Lever The throttle lever changes the engine speed. Move the throttle lever to Fast (1) to increase engine speed. Move the lever to Slo
GB - 14The alert starts counting down two hours before the maintenance is due. The meter flashes the word, "Now," when it reaches the mainte
GB - 15Fuel StabilizerGasoline left in the fuel system for extended periods without a stabilizer will deteriorate, resulting in gum deposits in the sy
GB - 163. Bring the steering levers to neutral. 4. Slow the engine down to about 3/4 speed. 5. Turn ON the PTO switch to engage the mower. IMPORTANT:
GB - 17Proper maintenance can prolong the life of unit. The following charts show the recommended service schedule. More frequent service may be requi
GB - 18Ariens Dealers will provide any service which may be required to keep your unit operating at peak efficiency. Should engine service be required
GB - 19HYDRAULIC FLUIDCheck Hydraulic Fluid LevelCheck the system with the unit cold and parked on a flat, level surface. Then run the unit for about
GB - 2Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . 4Assembly . . . . . . . . . . . . . . . . . . . . . . . 10Controls and Features. .
GB - 207. Fill with 20W-50 engine oil with an SL API classification until oil appears at the bottom of the drain plug (about 2 quarts per transaxle).
GB - 21Sharpen the Mower Blades1. Remove mower blade from unit.Discard mower blade if:• More than 1/2 in. (1.27 cm) of metal is removed.• Air lifts be
GB - 221. Remove battery from unit. See Remove Battery on page 21.2. Clean terminals and battery cable ends with wire brush.3. Coat terminals with die
GB - 234. Start the engine, run engine at full throttle, and release the parking brake.5. Move the steering levers from Forward to Reverse several tim
GB - 24ADJUSTING THE UNIT TO TRACK STRAIGHTCheck and adjust tire pressure. Increase pressure on side unit tracks to. DO NOT exceed maximum recommended
GB - 25Check AdjustmentNOTE: Be sure to check the parking brake on both sides of the unit (Figure 17). 1. Engage parking brake and set both transmissi
GB - 264. Remove short mower belt from right blade spindle and from deck. Idler pivot bolt must be loosened slightly to gain clearance to remove belt
GB - 27MOWER DECKSAnti-scalp Roller Adjustment The anti-scalp rollers are set at the factory for typical mowing height, but can be adjusted for high o
GB - 28Installing the Mower Deck (Figure 23) 1. Slide mower deck under unit.2. Connect mower mounting arms to deck with mower mounting pins.3. Install
GB - 29Adjust Blade HeightLevel and pitch the mower with the height adjusters on each deck lift bracket (Figure 25).Loosen the jam nut on the deck lif
GB - 3• Record Unit Model and Serial numbers here.• Record Engine Model and Serial numbers here.PRODUCT REGISTRATIONThe Ariens dealer must register th
GB - 30SHORT TERMNEVER spray unit with high-pressure water or store unit outdoors.Inspect unit for visible signs of wear, breakage or damage.Keep all
GB - 31SPECIFICATIONSModel Number 991085 991086 991087Model Max Zoom 48 Max Zoom 52 Max Zoom 60Engine KawasakiEngine Model Number FR691 FR730Engine
Con_Ride_201132Two-Year Limited Lawn and Garden Consumer Ride-On WarrantyAriens Company (Ariens) warrants to the original purchaser that Ariens, Grave
Con_Ride_201133To find an Ariens or Gravely authorized service representative, contact Ariens at:655 W. Ryan StreetBrillion, WI 54110(920) 756 - 2141w
CARB_EPA_201134 CALIFORNIA AND EPA (UNITED STATES ENVIRONMENTAL PROTECTION AGENCY) EVAPORATIVE EMISSION CONTROL WARRANTY STATEMENTYOUR WARRANTY RIGHTS
CARB_EPA_201135(4.) Repair or replacement of any warranted part under the warranty provisions of this article must be performed at no charge to the ow
The engine exhaust from this productcontains chemicals known to the Stateof California to cause cancer, birthdefects or other reproductive harm.WARNIN
GB - 4SAFETY ALERT SYMBOLThese are safety alert symbols. They mean: •ATTENTION! •YOUR SAFETY IS INVOLVED! When you see this symbol:•BECOME ALERT! •OB
GB - 51. DANGER! TO AVOID SERIOUS INJURY OR DEATHRead Owner/Operator Manual.Keep children and others away from unit while operating.Never direct disch
GB - 6Shut off engine, remove key, read manual before you adjust or repair unit.NO STEP! Always keep feet away from rotating parts.3. WARNING! Do not
GB - 7Inspect unit before each use for: missing or damaged decals and shields, correctly operating safety interlock system, and deterioration of grass
GB - 8Always stand clear of the discharge area.ALWAYS disengage PTO, stop unit and engine, remove key, engage parking brake and allow moving parts to
GB - 9Keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. Do not use a nozzle lock-o
Comments to this Manuals