Ariens Sno-Thro 924117 - 1024 User Manual

Owner/Operator Manual Models 924116 - 1028924117 - 1024924300 - 1024924505 - 1332924506 - 1336924508 - 1128 Sno-Thro ® 02494100E 4/02Supercedes 02494

GB - 10Never direct discharge towards persons or property that may be injured or damaged by thrown objects. Use extreme caution on gravel surfaces. S

GB - 11 Spark Arrester This product is equipped with an internal combustion type engine. DO NOT use unit on or near any unimproved, forest-covered or

GB - 12 ACCESSORY AND ATTACHMENT SAFETY RULES Use only attachments or accessories designed for your unit. Check components frequently. If worn or dam

GB - 134. Secure chute by fastening chute strap to engine with hardware just removed. NOTE: Washers and lock nuts go on top of chute strap.5. Loose

GB - 14 Check Function of Dual Handle Interlock Without the engine running, press down (engage) both clutch levers. Release attachment clutch lever.

GB - 15 Attachment Clutch - Right Hand Lever Squeeze Attachment Clutch Lever against handlebar (1) to engage attachment. Release both clutch levers (

GB - 16Discharge Chute DeflectorALWAYS position discharge chute deflector at a safe angle before starting engine.DO NOT throw snow any higher than neces

GB - 177. ALWAYS clean up any spilled fuel.PRE-START1. Frozen ImpellerIMPORTANT: Before starting engine, check impeller to be sure it is not frozen.To

GB - 18Electric Start (120V)1. Connect extension cord to prongs on starter.IMPORTANT: Prevent damage to unit. Know voltage of your starter and only us

GB - 19TRANSPORTALWAYS shut off engine, remove key and drain fuel when transporting unit on a truck or trailer.Use extra care when loading or unloadin

2 April, 2002MODEL CERTIFICATE OF CONFORMITY ISSUED BY THE MANUFACTURERCERTIFICAT DE CONFORMITÉ DU MODÈLE DÉLIVRÉ PAR LE FABRICANT MODELL-KONFORMITÄT

GB - 20CHECK CLUTCHESAuger / impeller must stop within 5 seconds when attachment clutch/impeller brake lever is released.Wheels must stop quickly when

GB - 21CLEAN BATTERY (924300, 505, 506, 508)IMPORTANT: Battery is maintenance free. Do not tamper with or attempt to open battery. See Service and Adj

GB - 22DEFLECTOR REMOTE (924116, 505, 506)Deflector must stay in selected position while throwing snow.If deflector does not stay in set position: 1. Ti

GB - 23SCRAPER BLADEIMPORTANT: Damage to auger/impeller housing will result if blade wears down too far.Scraper blade is adjustable to compensate for

GB - 24ATTACHMENT CLUTCH/BRAKE ADJUSTMENT(Figures 17 and 18)1. Remove belt cover. 2. Check belt alignment (Figure 20).Engine sheave and attachment pul

GB - 25TRACTION DRIVE CLUTCH ADJUSTMENTIf drive slips, adjust traction clutch to compensate for friction disc wear.To adjust traction clutch: 1. Place

GB - 26 Install new attachment drive belt: 1. Place new attachment belt onto attachment pulley.2. Tip housing and frame back together and secure with

GB - 277. Reconnect chute crank and secure with spring clip. If equipped, reconnect remote cap deflector cable and/or electric chute wire harness.8. R

GB - 28 SHORT TERM IMPORTANT: NEVER spray unit with high pressure water or store unit outdoors.Run with attachment clutch engaged a few minutes afte

GB - 29To obtain a complete parts manual, find your model and serial number. Then go to www.ariens.com or call 1-800-678-5443.* Available in CE countr

3 April, 2002Stated Sound Power Levels are established following Annex V “Internal Control of Production” of directive 2000/14/EC and assessment proc

GB - 30 SPECIFICATIONS Model Number 924116 924117 924300 924508 924505 924506Description 1028 1024 1024 1128 1332 1336 Engine - Tecumseh HMSK10-1594

GB - 31 Attachment Clutch Ye s Drive Disc-O-MaticSpeeds 6 Forward and 2 Reverse Lock Out Differential No Yes Pneumatic Tires - in (cm)16/6.50 x8 (40

GB - 323 Year Limited Sno-Thro WarrantyAriens Company warrants to the original purchaser that consumer products manufacturedby Ariens Company will be

Ariens Company655 West Ryan StreetP.O. Box 157Brillion, WI 54110-0157920-756-2141Fax 920-756-2407www.ariens.com

4 ENGLISH 1. Traction Drive Clutch Lever2. Throttle (Engine Stop)3. Choke Control Knob4. Differential Lock (924117, 300, 505, 506, 508)5. Ignition K

5Figure 1OS059512436522722262881621181991574121025291730311423201311

GB - 6 Controls and Features . . . . . . . . . . . . . . . . 4Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7Assembly. . . . . .

GB - 7 NOTE: To locate your nearest Ariens Dealer, call 1-800-678-5443 or go to www.ariens.com on the internet.2. Understand all Safety Precautions

GB - 8 SAFETY DECALS AND LOCATIONS ALWAYS replace missing or damaged Safety Decals. Refer to figure below for Safety Decal locations. 1. DANGER! 2. WA

GB - 9 3. DANGER! 4. HOT SURFACES! ASSEMBLY SAFETY RULES Read, understand, and follow all safety practices in Owner/Operator Manual before beginning